ford fusion sunroof drain location

I was told by the dealership today that the epoxy used to bond the moonroof glass to the seal was bad, causing the leak (mine was on the passenger side). For this particular vehicle, right below the run drain opening, I takes a tighter turn so something stiffer may cause issues. Open the driver front door. 2007 Fusion sunroof. So, this is a fairly recent problem. I never use the dang thing, sun makes it too hot to even open the shade except in winter here in the south. Guess that rough stretch of I-40 I was griping about shook it off! It works like a wick and absorbs and distributes the rain thru your headliner. I should have only poured a tiny bit. Most of the time it is closed so debris is not the root cause. You will see a "ditch" where the water gathers in the front. Your previous content has been restored. 4. Evaporator Drain, Includes Time To Install Elbow, Heat Shield Tape And Inspect Carpet For Dampness (Do Not Use With Any Other Labor Operations) 192345A 0.6 Hrs. Do Not Sell or Share My Personal Information -, By logging into your account, you agree to our, Ford Van History - Econoline and Transit (photos), The following errors occurred with your submission, Explorer, Sport Trac, Mountaineer & Aviator, Lightning, Harley-Davidson F-150, Roush F-150 & Saleen F-150, Conventional (Bumper Pull) Towing; Travel Trailers & Pop-ups, Toy Hauler Towing; Fifth Wheel & Bumper Pull, Flatbed, Car, Boat, Utility, Horse & Misc. My car is always parked on a slight incline with the front of the car pointing down. Check to see if the water is flowing out of the exits for the drain holes. Dealer has cleaned drain lines twice in 3 years under warranty. I have a 2010 Ford Fusion that in winter slush gets water in the drivers floor Water is leaking into the drivers floor. Reply Like 12-26-2011, 02:58 PM # 5 minnemike Senior Member Join Date: Feb 2011 Location: maplewood, MN Posts: 360 What causes a Ford sunroof motor to make a continuous clicking noise while trying to open it? Search and buy used Ford Fusion with sunroof. When broken, it does not pull the drain to the proper location, allowing the water to drain in the car. There may be a TSB on this. The dealership was smart enough to avoid a lawsuit by letting him get another car at a great discount. Come join the discussion about news, reviews, performance, modifications, classifieds, troubleshooting, maintenance, and more! Slowly insert the wire, trimmer cord is also great for this if you have a roll laying around. ford_leak Fusion Member 4 Region:U.S. Southern Atlantic My Fusion:Decline Author Posted October 4, 2020 Update: It is indeed leaking down the left (driver's) side, from the corner up behind the dash. Have had 6 cars with sunroofs, never a leakage issue. Post A portable airline and stiff electrical cable soon cleared the grime out. Do you know where the front drains exit? If I left it open inthe rear tilt-up position and forgot to close it and it rained, would there be drainholes for the water to get out?My old '89 mustang had drains holes that led to tubes than ran down to the bottomof the car. Weed whacker string from the bottom up. Thoughts? I keep getting a message that the board attachment quota has been reached. Great tips, thank you for sharing! Copyright 2023 Leaf Group Ltd. / Leaf Group Media. Here you will find fuse box diagrams of Ford Fusion 2011 and 2012, get information about the location of the fuse panels inside the car, and learn about the assignment of each fuse (fuse layout) and relay. Another instance for light reading: My Parents bought an '85 New Yorker 4cyl turbo new off the lot. Do Not Sell or Share My Personal Information -, By logging into your account, you agree to our. Problem solved. Glad the moonroof is more selectable than it used to be. By Apparently there is a drainage spot somewhere around here that can be blocked and cause flooding inside the vehicle. Archive - Should be an easy fix, the reason for the wait is because they probably have another company come out for water leaks. Resolution: The 2 drain tubes are 3/8 inch clear hose that run from the sunroof pan thru the roof pillars and down behind the kick panel in the foot well area. Locate the drain holes. I'm hoping that the clogged drains are why i suddenly have such a bad condensation problem inside my Hyundai Santa Fe. As the truck gets older the sunroof seal may contract a bit and let more water in. Then all of a sudden the leaks started happening. It is indeed leaking down the left (driver's) side, from the corner up behind the dash. Began in 2015 as a leak only when going through a car wash. If Ford leaves you out in the cold, just get a replacement moonroof from a junkyard based in a rust free portion of the US. There was a leak in a body seam under the cowl. Mar 3, 2021 Random guy walking dog better informational resource than the Org lol Probably just a clogged drainhole in the moonroof surround. TSB ID: 17-2235. Locate your sunroof's drains. Our problem now appears to be resolved. I later realized that the problem is with where the car was packed - directly under the nozzle exit of a house roof rain collecting pipe. When I drain the water seperator should I? Clear editor. Mine is 2006 Fusion. All site content Copyright 2007-var year=new Date(); year=year.getYear(); if (year<1900) year+=1900; document.write(year); FordFlex.net FordFlex.net is in no way affiliated with Ford Motor Company. Thats what we all use here. If you want to know where it exits just pour water around the edges of your sunroof and then watch under the car for it to come out. It's possible that a sunroof drain is clogged. 4 years ago Tools/Supplies Needed: soft wire or trimmer cord by TwoTone Wed Mar 11, 2020 6:52 am, Post I do not think this is a ford fusion specific issue, as i heard of someone having this issue with a bmw, but it flooded both sides of the car. They are not watertight. Posted by Anonymous on Nov 05, 2012. William Zane has been a freelance writer and photographer for over six years and specializes primarily in automotive-related subject matter among many other topics. What worked for me was a length of insulated 2-conductor indoor house wiring cable. CAR RETURNED TO US. Search by Part Number(s), Keywords, or VIN. 2010 ford fusion sunroof is stuck open in vent position, three weeks, 84000, bout used one month ago. They all have drain tubes. Ibe watched several.youtube videos suggesting using weed trimmer cord. JavaScript is disabled. Sucks about the wait, and I'm sorry about the frustration on such a new car, but let's hope they can get it in and resolved quickly. When you purchase through links on our site, we may earn an affiliate commission, which supports our community. All they do to fix the problem is get a can of compressed air & blow the tube out. Share it with us! I had a similar problem in my 2015 Super Duty. Re: Cleaning out the Sunroof/Vista Roof drains. Yep. You have to drill out these rivets and power the glass back and forward to get the guides and rods out. I don't even WANT the Moonroof but I've got to buy it as it's packaged with the SONY Stereo. All site content Copyright 2006-var year=new Date(); year=year.getYear(); if (year<1900) year+=1900; document.write(year); FordFusion.net We are in no way affiliated with Ford Motor Company, Items relating to recalls, technical service bulletins, maintenance, and care go here. at first i thought the sunroof drains were clogged causing it to leak. Howdy Super Duty Fans! I am sure that the car has had this problem forever and that it only got bad after enough dirt had flushed down the drain tubes (yes, there was plenty of dirt there) to clog up the smallish holes in the semi-porous foam stuff. Contact your local Ford, Lincoln or Mercury dealer for details and a copy of the limited warranty. This information has been great and has help me identify the front drainage tubes. MINE WAS BLOCKED DRAINS . found a seam where the floor pan meets the firewall that was supposed to be sealed with some kind of foam or silicone. In this video I show how we fixed a leaking sunroof on a 2012 Ford Focus. When a sunroof drain does become plugged, the common signs are either a wet headliner, water dripping from the headliner, wet roof pillar, a damp carpet or water pooling in the foot wells. I only found the A section wet twice, which was after really heavy rain and the car was on an angle so it couldn't drain through the rear drainage tubes. Your link has been automatically embedded. Of course what helped her case was the dealer service dept. Or there could be a bad seal somewhere. The tube just ends (and drains into) a small cavity/pocket formed where several pieces of body sheet metal meet. It runs well and the bells and whistles are great. I have the hybrid fully loaded and my moonroof began leaking down the side. Location; Windshield: Feb 2023: Malta, NY: Windshield: Feb 2023: HEMPSTEAD, NY . If the car is parked "flat" there is no obvious water accumulation. The drain hoses through the roof pillars should be at least 3/6" I.D. Though the sunroof is sealed to keep most moisture out, some moisture and water does come in through the gap between the sunroof and the car itself. BEWARE FUSION OWNERS W/MOON. . Ultimately, if anyone else has this problem it may be a great help. This is the plastic piece that ususally breaks. After a torrential rain, the foot mat at the driver's get waterlogged sometimes spilling over to the other side and backwards. Some photos from yesterdays drying out session. For a better experience, please enable JavaScript in your browser before proceeding. The water drips in around the sunglass holder/dome lights. I felt the roof and sure enough it was pretty saturated with water. Consult a workshop manual for your specific model. Dang! I've done this today as i suspected blocked sunroof drains. I found two drain holes in the sunroof on the front of the sunroof are there any in the back. 10/21/17. You can post now and register later. Cookie Policy - I also occasionally open the sunroof and wipe around the gaskets and drain inlets when I wash my car, which admittedly isn't often enough. If the air compressor does not work or you do not have access to one, use a wire. AFTER MARKET sun roofs do NOT have gutters formed into the roof to collect rain, since the fitter simply cuts a hole into roof and installs a grommet that has as built in channel to drain rain via a tube down via the "A" pillar. a few days ago. Privacy Statement - ok, I cant find a picture, but if you stick your head under the passenger side dash below the glove box and look right where the heater box meets the firewall of the engine bay (you will need to move floormat and maybe even pull edge of carpet back a bit) you will see a plastic tube that comes from that lower edge of the heater case and goes through the engine bay firewall. Contact Us - Gotten progressively worse. Tools/Supplies Needed: -soft wire or trimmer cord This car was put away for the winters and it was like new. First, I read other related posts here to familiarize myself with known issues. Take the vehicle to a professional service provider if you continue to have problems with the sunroof. If that doesn't do the trick, try running a very small flexible "plumbing" snake down the tube to break up the clog. Question Got the drain tube out of its location and pulled it up thru the gap at the side of the A pillar,with the A pillar cover removed,i then drilled the oneway valve out at the pipe end,and a pile a black sh1ty sludge came out followed by plenty of clear water. Thanks for the update. A sunroof drainage system is commonly present in every model of Ford, like F150, F250, and F350 from 2000 to 2022. Location: Southeastern PA Leaking Sunroof by poff Sun Apr 25, 2010 11:32 pm I have a 2007 Milan (I am the original owner) and the sunroof started leaking. by the plastic piece that is around the front edge of the glass. SPRAY TEST WAS NEGATIVE FOR LEAKS. It will likely be the 2 front moonroof drains that are clogged. There was a spot where the sealer had not been applied correctly at the factory. . Ford 2018-2020 Expedition 2018-2020 F-150 2018-2020 F-Super Duty Lincoln . Quote 08Fusion Fusion Member 53 Posted May 17, 2008 Or there could be a bad seal somewhere. BOUGHT NEW IN JUNE 09. I've had a Cougar and a Mustang with a Moonroof. Post I took it to Nu-Look auto in Haymarket, VA. Subject: 2012 Ford Escape premium care warranty for Sunroof. I don't know how to make repairs so I'm going to have to take it to the dealership and get it fixed. Dropping the corner of the headliner is easy. After that, remove the wire or cord. OOPS! The carpets are soaked under both seats and some . Anyone know what the problem is or how to fix? & 303A. I had to prove I had dropped my claim. They were courteous and polite and as sympathetic and accomodating as they could be under the circumstances. Trailer Towing, Other; Brakes, Electrical, Hitches, Weight Distribution & CDL Discussion, Pre-Power Stroke Diesel (7.3L IDI & 6.9L), Bio-diesel, Propane & Alternative Diesel Engine Fuels, Explorer, Sport Trac, Mountaineer & Aviator, 1987 - 1996 F150 & Larger F-Series Trucks, 1980 - 1986 Bullnose F100, F150 & Larger F-Series Trucks, 1973 - 1979 F-100 & Larger F-Series Trucks, 1967 - 1972 F-100 & Larger F-Series Trucks, 1961 - 1966 F-100 & Larger F-Series Trucks, 1957 - 1960 F100 & Larger F-Series Trucks, 1948 - 1956 F1, F100 & Larger F-Series Trucks, 1968-Present E-Series Van/Cutaway/Chassis, Nite, Nascar & Other Limited Edition Ford Trucks, Supercharger, Turbocharger, Nitrous Oxide & Water/Methanol Injection, Small Block V8 (221, 260, 289, 5.0/302, 5.8/351W), Big Block V8 - 385 Series (6.1/370, 7.0/429, 7.5/460), FE & FT Big Block V8 (332, 352, 360, 390, 406, 410, 427, 428), 335 Series- 5.8/351M, 6.6/400, 351 Cleveland, Y-Block V8 (239, 272, 292, 312, 317, 341, 368), Audio & Video Systems, Navigation, Satellite Radio & Mobile Electronics, Bed Covers, Tonneau covers, Toppers/Canopies & Bed liners, Brakes, Steering, Suspension, Tires, & Wheels, Clutch, Transmission, Differential, Axle & Transfer Case, Fuel Injection, Carburetion & Fuel System, Vendor Specials, Discounts, Product Announcements & Group Buys, Find all posts by Crotchety Ford truck only, 2023 Super Duty Order Tracking / No Off Topic Please, https://www.f150forum.com/f118/10-minute-sunroof-leak-fix-409873/, Do Not Sell or Share My Personal Information. When the sunroof pan fills up, or if you deliberately plug the drain holes, the water has nowhere to go and will certainly (if only slowly) drain into the cabin. Display as a link instead, Location: Austin, Texas Posts: 793 Likes: 38 Received 18 Likes on 10 Posts Where are the Sunroof Drains Located? I hope this helps some of you. Water is coming in under the dashboard on the driver's side, apparently on the left side next to the door.

Flemish Giant Rabbit For Sale Georgia, Reed Timmer And Ginger Zee Engaged, Calworks Homeless Assistance Program 2021, Accident On Northway Yesterday, Hawaii Restaurants Closed Due To Covid, Articles F